Turbosmart IWG75 Single Port Internal Wastegate Actuator
Turbosmart IWG75 Single Port Internal Wastegate Actuator
Turbosmart IWG75 Single Port Internal Wastegate Actuator
Turbosmart IWG75 Single Port Internal Wastegate Actuator
**For Twin Port EFR applications, check out Turbosmart's new GenV actuator.
- Base spring pressure available from 3PSI to 26PSI
- Stable boost control
- Improved boost response
- Flatter boost curve in the top end
- A range of vehicle/turbo specific applications
The wastegate actuator allows for different combinations of spring pressures. All springs that are adaptable with the wastegate actuator are shown in the table below. To aid in the identification of these springs they are supplied colour coded. If this colour coding is not clear please use the dimensions in the following table to identify the spring. The springs chosen should be rated to the lowest boost level desired. Typically with a single port IWG, the stiffer the spring the earlier a given turbo will spool, since the WG does not bypass any exhaust gas during spoolup.
WARNING!
- Fitting a heavier wastegate actuator spring may cause a higher than expected increase in boost pressure.
- Turbosmart recommends adjusting your boost controller back to its minimum setting (or unplugging the solenoid) and measuring the new minimum boost pressure achieved by the new spring, before increasing your boost pressure again.
- Use of a turbocharger speed sensor is a good idea if you plan to run very high boost levels
If a 3 Port Boost Control Solenoid is used, this is the correct plumbing orientation diagram:
Â
SKU
TS-IWG-SINGLEPORT
WEIGHT
2.000000
BRAND
Turbosmart
You may also like:
Full-Race T4 Divided 5 Layer Inconel Gasket
2012-2013 9th Gen Honda Civic | Traction Balls
Full-Race EFR Oil Drain Flange
BorgWarner EFR 3" Downpipe V-band Flange
Full Race 3" EFR V-Band Clamp
BorgWarner EFR Turbo Installation Kit
Turbosmart EFR Compressor Housing BOV Block Off Plate
BorgWarner EFR 6258 Turbo
Garrett GTX2860R Gen II Turbo
PTP BorgWarner EFR Turbo Blanket
similar products
2011-2016 F150 EcoBoost 3.5L Gen 1 Wastegate Actuator
Garrett PowerMax 2011-2016 Ford 3.5L F150 EcoBoost Stage 1 Bolt-On Twin Turbo Upgrade
Full-Race Ford F150 EcoBoost 3.5L Billet Turbo Oil Return Fitting -10 AN Male
Full-Race Formline Turbo Kit for 2011-2016 3.5L F150 EcoBoost
Full-Race 2011-2014 Ford F150 EcoBoost Intercooler Kit
Turbosmart Vee Port Electronic Blow Off Valve Ford F150 EcoBoost Raptor 2.7L 3.5L 2013+
Turbosmart BorgWarner EFR and Ford EcoBoost Kompact Plumb Back
Full-Race 2011-2014 Ford F-150 and Gen1 Raptor Radiator Upgrade
Xtreme-DI XDI Ford EcoBoost HPFP | Direct Injection High Pressure Fuel Pump Upgrade For Ford EcoBoost
Full-Race Ford F-150 3.5L Ecoboost Twin Turbo Install Kit
2011-2020 F150 3.5L EcoBoost Billet Turbo Adapter Kit
Full-Race Formline 3.5L Gen1 EcoBoost F-150 Turbo Manifolds (2011-2016)
For SHOP OWNERs
& KIT BUILDERs
Full-Race Motorsports is the most
trusted name in turbocharging.